Alu Plus

Document Header: ENVIROCHEM INTERNATIONAL (NZ) LTD | www.envirochem.co.nz — Page 1 of 5

Safety Data Sheet

Product Name: Alu Plus

Recommended Use: Metal Cleaner and Rust Treatment Chemical

Company Details: Envirochem International (NZ) Ltd

Address: 41 Angle Street, Onehunga, Auckland, New Zealand

Telephone Number: +64 9 262 0800

Emergency Telephone Number: National Poison Information Centre 0800 764 766

Date of Preparation: 01/06/2017

Signal Word: DANGER

HSNO Hazard Classification: 6.1D (oral), 6.7A, 6.9A, 6.9B (inhale), 8.1A, 8.2B, 8.3A, 9.1D, 9.3C

Hazard Statements:

• Harmful if swallowed
• May cause cancer
• Causes damage to organs by skin contact
• May be corrosive to metal
• Causes severe skin burns and eye damage
• Causes serious eye damage
• May cause long lasting harmful effects to aquatic life
• Harmful to terrestrial vertebrates

Prevention Statements:

• Keep out of reach of children
• Read label before use
• Wash hand thoroughly after handling
• Do not eat, drink or smoke when using product
• Obtain special instructions before use
• Do not use until all safety precautions have been read and understood
• Use personal protective equipment as required
• Do not breath dust/mist
• Keep in original container
• Avoid release into environment

Response Statements:

• If medical advice is needed, have product container or label at hand
• If swallowed rinse out mouth and do not induce vomiting. Call POISON CENTER or doctor/physician if you feel unwell.
• Rinse mouth
• If exposed or concerned: Get medical advice/attention
• If exposed: Call a POISON CENTRE or doctor/physician
• Absorb spillage to prevent material damage
• If swallowed: Rinse mouth DO NOT induce vomiting
• If on skin (or hair): Remove/Take off immediately all contaminated clothing. Rinse skin with water/shower
• Wash contaminated clothing before use
• If inhaled: remove to fresh air and keep at rest in a position comfortable for breathing
• Immediately call a POISON CENTRE or doctor/physician
• If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do, continue rinsing

Storage Statement:

• Store locked up

Disposal:

• Disposal should be through qualified contractor.

Ingredients:

Ingestion: Immediately rinse mouth with water. If swallowed do not induce vomiting. Give water to drink. Never give anything by mouth to an unconscious person. Seek immediate medical aid immediately.

Eye Contact: Immediately flush eyes with large amounts of water for at least 15 minutes while holding eyelids open. Transport to the nearest medical facility for additional treatment. Do not rub eyes or keep eyes closed.

Skin Contact: Remove contaminated clothing. Flush exposed area with water and follow by washing with soap if available.

Inhalation: Remove the affected person out to a ventilated area. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Seek medical attention.

Extinguishing Media: Use dry chemical powder, foam, polymer foam, and water spray or fog type extinguishers. Water may be ineffective on fire. However, water spray may be used to extinguish fires and to absorb heat. Keep containers cool and protect exposed material. If a leak or spill has not ignited, water spray may be used to flush spills away from exposures.

Hazards from Combustion Products: Not combustible. However, following evaporation of aqueous component, residual material can burn if ignited. While burning, it will emit toxic fumes including carbon monoxide and carbon dioxide.

Precautions for Fire Fighters and Special Protective Equipment:

• Alert fire brigade and tell them location and nature of hazard.
• Wear breathing apparatus plus protective gloves.
• Prevent, by any means available, spillage from entering drains or water courses.
• Use fire fighting procedure suitable for surrounding area.
• Use water delivered as a fine spray to control the fire and cool adjacent area.
• Fire fighters to wear self-contained breathing apparatus if risk of exposure to vapour or products of combustion as well as structural fire fighter uniform.

Emergency Precautions:

Personnel involved in the clean up should wear full protective clothing. Evacuate all unnecessary personnel. Increase ventilation. Avoid walking through spilled product as it may be slippery. Stop leak if safe to do so. Do not let product reach drain or waterways; advise the Environmental Protection Authority or your local Waste Management. Use clean, non-sparking tools and equipment.

Methods and Materials for Containment and Clean Up:

Soak up spilled product using absorbent, non-combustible material such as sand or soil. Avoid using sawdust or cellulose. When saturated, collect material into suitable, labelled, dry, sealable containers and hold for safe disposal. Once pick-up is complete, flush spill site with plenty of water to eliminate any residue. Hold contaminated water for treatment/disposal.

Handling: Wash thoroughly after handling. Use only in a well ventilated area. Avoid contact with eyes, skin and clothing. Empty containers retain product and residue (liquid or vapour), and can be dangerous. Keep container tightly closed. Always wash hands before smoking, eating or using the toilet. Wash contaminated clothing and other protective equipment before storage or re-use. Do not dispose of material to sewers or waterways.

Storage: Store in a tightly closed container. Keep from contact with oxidizing agents. Store in cool, dry, well-ventilated area away from incompatible substances. Keep containers closed at all times, check regularly for leak.

Exposure Standards: The Occupational Safety and Health Service, NZ Department of Labour have set no Tolerable Exposure Limit (TEL) Workplace Exposure Standards (WES) for this substance.

Biological Limit Values: None established

Engineering Controls: The use of local exhaust ventilation is recommended to control process emissions near the source. Laboratory samples should be handled in a fume hood. Provide mechanical ventilation of confined spaces. Use explosion proof ventilation equipment.

Personal Protective Equipment:

Respiratory Protection: Where concentration in air may exceed the limits described in the National Exposure Standards, it is recommended to use a half face filter mask to protect from overexposure by inhalation. A type u201cAu201d filter material is considered suitable for this product.

Eye Protection: Always use safety glasses or a face shield when handling this product.

Skin/Body Protection: Always wear long sleeves and long trousers or coveralls, enclosed footwear or safety boots and chemical resistant gloves when manufacturing this product.

Document Header: ENVIROCHEM INTERNATIONAL (NZ) LTD | www.envirochem.co.nz — Page 4 of 5

Appearance: Clear green

Physical State: Liquid

Odour: Odourless

pH: 1u20133

Solubility: Soluble in water

Vapour Density: Not available

Boiling Point: >100 °C

Freezing Point: 0 °C

Ignition Point: Not available

Flash Point: Not available

Specific Gravity: Not available

Vapour Pressure: Not available

% Volatiles: Not available

Chemical Stability: Stable at room temperature and pressure

Conditions to Avoid: Avoid excessive heat, direct sunlight, moisture, high temperatures

Incompatible Materials: Incompatible with acidic agents, including acidic clays and sources of ignition

Hazardous Decomposition: When involved in a fire, this product will generate carbon monoxide

Hazardous Reactions: Oxidizing agents, mineral acids, halogenated organic compounds

No adverse health effects expected if the product is handled in accordance with the safety data sheet. Symptoms or effects that may arise if the product is mishandled and overexposure occurs are as follows:

Acute Effects

Ingestion: Small amounts of liquid aspirated into lungs during ingestion, or from vomiting. Ingestion of large amounts of this product will result in headaches, nausea, dizziness and tracheal burning.

Eye Contact: This product is irritating and pain followed by swelling to the conjunctiva.

Skin Contact: This product is irritating to skin.

Inhalation: Irritating to respiratory tract. Exposure to high concentrations over an extended period of time may result in muscle weakness, tingling in hands and feet, blurred vision, headaches, nausea, loss of appetite, hallucinations and possible loss of consciousness.

Chronic Effects: This product contains sulphuric acid, a confirmed toxicant to target organs and systems, and may cause cancer.

Other Health Effects Information: The effects of the constituents of this product can cause severe skin burn and eye damage.

Toxicological Information: Actual oral toxicity LD50 396 mg/kg.

Persistence/Degradability: The substance is expected to be persistent.

Mobility: No data available for this product.

Disposal Methods: Empty packaging should be taken for recycling, recovery or disposal through a suitably qualified or licensed contractor. Care should be taken to ensure compliance with national and local authorities. Packaging may still contain fumes and vapours that are flammable and harmful.

Special Precautions for Landfill or Incineration: This product is not suitable for disposal by either landfill or via municipal sewers, drain, natural streams or rivers. This product is ashless and can be burned directly in appropriate equipment.

Road and Rail Transport: Classified as Dangerous Goods by the criteria of New Zealand Dangerous Goods Code for transport by road and rail.

Marine Transport: Classified as Dangerous Goods by the criteria of International Maritime Dangerous Goods Code for transport by sea.

Air Transport: Classified as Dangerous Goods by the criteria of International Air Association Dangerous Goods Regulations for transport by air.

Shipping Name: CORROSIVE TOXIC LIQUID, N.O.S., contain hydrofluoric acid, phosphoric acid and sulphuric acid

Hazard Class: 8/6.1

UN Number: UN 2922

Packing Group: II

Hazchem Code: 2XE

HSNO Approval No: HSR002588

Group Standard: Cleaning Products Toxic (6.7) Group Standard 2006

HSNO Classification: 6.1D (oral), 6.7A, 6.9A, 6.9B (inhale), 8.1A, 8.2B, 8.3A, 9.1D, 9.3C

Document Footer: ENVIROCHEM INTERNATIONAL (NZ) LTD | www.envirochem.co.nz — Page 5 of 5

New Zealand National Poison Information Centre: 0800 764 766

New Zealand Emergency Services: 111

Envirochem International (NZ) Ltd: +64 9 262 0800

Disclaimer: Every endeavour has been made to ensure that the information contained in this publication is reliable and offered in good faith. It is meant to describe the safety requirements of our products and should not be construed as guaranteeing specific properties. Customers are encouraged to conduct their own tests as end user suitability of the product for particular uses is beyond our control. The information is not intended as an inducement to bargain and no warranty expressed or implied is made as to its accuracy, reliability or completeness. Envirochem International (NZ) Limited accepts no liability for loss, injury or damage arising from reliance upon the information contained in this data sheet except in conjunction with the proper use of the product to which it refers. Due care should be taken that the use and disposal of this product is in compliance with appropriate Local Councils regulations.